The effect of insulin on hepatic triglyceride synthesis and secretion is controversial. Previously, we have described a cell culture system of adult rat hepatocytes that synthesize and secrete very low density lipoprotein (VLDL) triglycerides with small and irreproducible effects of insulin on triglyceride metabolism. To study the primary effects of insulin on hepatic triglyceride metabolism a method was developed utilizing fibronectin-coated culture dishes that allowed adhesion, spreading, and maintenance of hepatocytes for 2-3 d in the absence of serum and insulin. This culture system allowed mass measurements of both cellular and secreted VLDL triglycerides for long time periods after the addition of physiological concentrations of insulin to hormone-free culture medium. In the absence of insulin and after an initial 4 h in culture, the medium was replenished and triglyceride mass was measured at the end of 18-h incubations. VLDL triglyceride accumulated in the culture medium at a linear rate over this time-course with increasing accumulation as the medium glucose concentration was raised from 2.5 to 25 mM glucose (1.77±0.24 to 3.09±0.76 μg triglyceride/mg cell protein per h). There was no apparent significant lipolysis or hepatocellular reuptake of secreted VLDL triglycerides. In the absence of insulin cellular triglyceride levels were unchanged between 3 and 24 h in culture while insulin (50-500 μU/ml) significantly increased cellular triglyceride content at all glucose concentrations tested (0-25 mM). The addition of insulin to the culture medium progressively reduced the rate of VLDL triglyceride secretion accompanied by an increase in cellular triglyceride at insulin concentrations > 50 μU/ml. Most or all of the observed increase in cell triglyceride content could in all experiments be accounted for by the insulin-induced inhibition of VLDL secretion. Incorporation of [2-³H]glycerol into cellular and VLDL triglycerides as a function of insulin concentration was also measured. Glycerol incorporation data at 20-22 h after plating of the cells closely paralleled the insulin-induced changes in cellular and VLDL triglyceride as determined by mass analysis. The observed effects of insulin occurred at concentrations close to the physiological range and suggest that the direct hepatic effect is to suppress VLDL secretion although the net effect in vivo will clearly reflect many additional accompanying changes.